Product ID:KLINGER K-61
MSDS Date:02/28/1992
FSC:5330
NIIN:01-268-7031
Status Code:A
MSDS Number: CKSZV

KLINGER RICHARD INC

2350 CAMPBELL RD
SIDNEY, OH 45365-9501
US

Emergency Phone: 937-498-1181

Info Phone: 937-498-1181

Cage: 9U500

KLINGER RICHARD INC

SIDNEY, OH 45365-9501 US

Telephone: 937-498-1181

Cage: 9U500

NATURAL RUBBER

STYRENE BUTADIENE RUBBER

CAS: 9003-55-8

RTECS: WL6478000

CHRYSOTILE ASBESTOS

CAS: 12001-29-5

RTECS: CI6478500

OSHA PEL 0.2 F/CC

ACGIH TLV: 0.2 F/CC

CARBON BLACK (BLACK ONLY)

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

TITANIUM DIOXIDE (WHITE ONLY)

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 10 MG/M3

ACGIH TLV: 10 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:CHRONIC CONDITIONS SUCH AS PLEURAL
PLAQUE, ASBESTOSIS, LUNG CANCER & MESOTHELIOMA MAY RESULT FROM
BREATHING FREE ASBESTOS FIBERS. INGESTION HAS BEEN WEAKLY LINKED TO
GASTROINTESTINAL CANCER. SKIN CONT ACT MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:IARC MONOGRAPHS - 2A
Effects of Overexposure:DIFFICULTY BREATHING, CHEST PAIN, COUGHING, AND
FINGER CLUBBING OFTEN ACCOMPANY ASBESTOS - RELATED RESPIRATORY
DISEASES.
Medical Cond Aggravated by Exposure:INHALATION OF ASBESTOS FIBERS MAY
IRRITATE THE UPPER RESPIRATORY TRACT, MAY EXACERBATE PRE-EXISTING
CONDITONS SUCH AS CHRONIC BRONCHITIS OR ASTHMA.

First Aid:INHALATION - MOVE TO FRESH AIR. SEEK MEDIACAL ATTENTION. SKIN
CONTACT-FREQUENT WASHING WILL DETER TRANSITORY CHEMICAL OR
SECHNICAL DERATITIS. EYE CONTACT-FLUSH WITH WATER FOR 15 MINUTES,
SEEK MEDICAL ATTENTION IF DISCOMFORT PERSISTS. INGESTION- INDUCE
VOMITING, SEEK MEDICAL ATTENTION.

Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER, CARBON DIOXIDE, DRY POWDER OR FOAM.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SCBA FOR PROTECTION
AGAINST TOXIC DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:WHEN GROUND, CLOUDS OF RUBBER PARTICLES
FINER THAN 840 US MAY PRODUCE A WEAK EXPLOSION. ALSO, ONCE RUBBER
IS EXTINGUISHED, PROVIDE EXTRA COOLING TO PREVENT SPONTANEOUS
REIGNITION.

Spill Release Procedures:TREAT DUST AS FREE ASBESTOS. DO NOT DRY SWEEP
OR USE COMPRESSED AIR. USE HEPA VACUUMS AND OR WET METHODS. AVOID
BREATHING DUST.

Handling and Storage Precautions:IN NORMAL HANDLING OF SHEETS AND CUT
GASKET NO SIGNIFICANT RELEASE OF ASBESTOS OCCURS. WHERE DUST
PRODUCING ACTIVITIES OCCUR, LOCAL VENTILATION, RESPIRATORS, HEPA
VACUUMS, AND WET METHODS SHOULD BE US ED TO ENSURE CONTAINMENT OF
RELEASED FIBERS.
Other Precautions:WHEN COMBINED WITH SMOKING, THE RISK OF
ASBESTOS-RELATED DISEASES INCREASES UP TO 25 TIMES.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR IF PEL IS
EXCEEDED (SEE TABLE 1 OF ASBESTOS STANDARD).
Ventilation:LOCAL EXHAUST. MECHANICAL/GENERAL IF LEVELS EXCEED PEL.
Protective Gloves:RECOMMENDED
Eye Protection:RECOMMENDED
Other Protective Equipment:NOT NORMALLY REQUIRED
Work Hygienic Practices:AVOID CREATING DUST. AVOID BREATHING DUST. USE
PERSONAL PROTECTIVE EQUIPMENT. PRACTICE GOOD HOUSEKEEPING AND GOOD
PERSONAL HYGIENE PROCEDURES. DO NOT SMOKE.
Supplemental Safety and Health
ABILITY OF GASKET TO MAKE SEAL DEPENDS ON QUALITY OF MATERIAL, MEADIUM
BEING SEALED, GASKET THICKNESS, FLANGE DESIGN, PRESSURE APPLIED &
HOW GASKET IS ASSEMBLED INTO FLANGES. USER MUST INSURE PRODUCT IS
SUITABLE FOR INTENDED USE. APPLICATION OF RELEASE AGENTS MAY CAUSE
GASKET FAILURE.

HCC:Z1
Boiling Pt:B.P. Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:1.75 G/CC
Evaporation Rate & Reference:NA
Solubility in Water:INSOLUBLE
Appearance and Odor:COMPOSITE MATL COMES IN BLACK & OFF WHITE COLORED
SHEETS OF VARYING THICKNESS.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDZERS, STRONG ACIDS AND BASES.
Hazardous Decomposition Products:POSSIBLE PYROLYTIC PRODICTS FROM
STYRENE BUTADIENE RUBBER SUCH AS FORMALDEHYDE, STYRENE, BENZENE,
ACROLIN, CO, CO2, AND OTHER AROSATIC AND ALIPHATIC HYDROCARBONS
SHOULD BE CONSIDERED TOXIC.

Waste Disposal Methods:APPROVED LANDFILL IN ACCORDANCE WITH FEDERAL,
STATE OR LOCAL LAWS AND ORDINANCES. INCINERATION IN A SUITABLE
COSBUSTION CHAMBER (> 1,800 C)

Toxicological Information:NOT PROVIDED

Ecological:NOT PROVIDED

Transport Information:NOT PROVIDED

Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:NOT PROVIDED

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.